Polymer composition with phenanthrenequinone for recording relief holographic gratings

Mahilny U.V., Khramtsou E.A., Shkadarevich A.P. Polymer composition with phenanthrenequinone for recording relief holographic gratings. Scientific and Technical Journal of Information Technologies, Mechanics and Optics, 2023, vol. 23, no. 2, pp. 211–217 (in Russian). doi: 10.17586/2226-1494-2023-23-2-211-217

The formation of periodic reliefs of the thickness of photosensitive polymer layers after recording holographic gratings in them and stimulating material deformations by reversible plasticization in a non-solvent liquid is considered. The phenomenon was studied for the composition of a copolymer with side anthracene groups — phenanthrenquinone. Phenantrenquinone transfers the energy of electronic excitation to oxygen molecules entering through the open surface of the polymer layer which then cause the oxidation of anthracene fragments. Holographic gratings with a period of 2–5 μm were recorded by laser radiation at a wavelength of 532 nm in layers about 1 μm thick. The photoreliefs were formed during the subsequent swelling of the layer in the medium of a hydrocarbon developer. The photosensitized oxidation of the anthracene groups of the new polymer under the action of optical radiation in the spectral range 408–532 nm was studied using the electron absorption spectra. It is shown that approaching the excitation wavelength to the long-wavelength absorption maximum of phenanthrenquinone (410 nm) makes it possible to increase the sensitivity of the material layer by a factor of 15 compared to layers with methylene blue as a photosensitizer. It has been experimentally established that the amplitude of weak periodic reliefs of a deformation nature (height less than 0.01 μm), which appear immediately after the recording of holographic gratings, increases many times during the treatment of the layer with liquid hydrocarbon. Their maximum value reaches 25 % of the thickness of the recording layer. Presumably, the deformation of the inhomogeneously irradiated layer is stimulated by the transfer of the polymer material into a highly elastic state during its swelling. Photoreliefs are stable after drying. Their strength can be increased by photocrosslinking the material as a result of photodimerization of residual anthracene groups under uniform irradiation with light at a wavelength of 365 nm. The non-sinusoidality of the photorelief reduces the diffraction efficiency achievable with total reflection to values less than 0.20. The studied polymer composition can be used to form relief-phase diffractive optical elements by radiation in the blue-green region of the spectrum, provided by a number of high-power laser sources.

1. Sukhanov V.I., Lashkov G.I., Petnikov A.E., Ashcheulov Yu.V., Reznikova I.I., Cherkasov A.S. Recording of phase holograms on an organic polymeric material with a dispersion that changes due to triplet-sensitized processes. Optical Holography. Collected Papers. Ed. by Yu.N. Denisyuk. Leningrad, Nauka, 1979, pp. 21–42. (in Russian)

2. Sukhanov V.I. Phase holograms in recording media with dispersive refraction. Soviet Physics Uspekhi, 1986, vol. 29, no. 3, pp. 289–290. https://doi.org/10.1070/pu1986v029n03abeh003214

3. Lashkov G.I. Energy transport involving triplet states in phase recording of light. Soviet Physics Uspekhi, 1986, vol. 29, no. 3, pp. 288–289. https://doi.org/10.1070/pu1986v029n03abeh003207

4. Sukhanov V.I., Veniaminov A.V., Ryskin A.I., Nikonorov N.V. JSC SOI developments in the field of volumetric recording media for holography. Proc. of the All-Russian Seminar "Yuri Nikolaevich Denisyuk - the founder of domestic holography". St. Petersburg, ITMO, 2007, pp. 262–276. (in Russian)

5. Mahilny U.V., Stankevich A.I., Khramtsov E.A. Polymeric material for direct recording of phase volume holograms in "red" spectral range. Collection of research papers of the IX International Conference Photonics and Information Optics. Moscow, NRNU MEPhI, 2020, pp. 651–652. (in Russian)

6. Mahilny U.V., Stankevich A.I., Khramtsou E.A., Shkadarevich A.P. Volume holographic material for red spectral range based on polymer with anthracene side groups. Journal of Applied Spectroscopy, 2021, vol. 88, no. 1, pp. 146–152. https://doi.org/10.1007/s10812-021-01153-z

7. Mahilny U.V., Stankevich A.I., Khramtsou E.A., Shkadarevich A.P. Photorefractive and relief-forming holographic material. Collection of research papers of the XI International Conference Photonics and Information Optics. Moscow, NRNU MEPhI, 2022, pp. 629–630. (in Russian)

8. Mogil’nyi V.V., Gritsai Yu.V., Kovalev S.V. Periodic surface photoreliefs in glassy and hyperelastic polymers. Technical Physics, 1999, vol. 44, no. 8, pp. 941–944. https://doi.org/10.1134/1.1259410

9. Veniaminov A.V., Lashkov G.I., Ratner O.B., Shelekhov N.S., Bandyuk O.V. Holographic relaxometry as a method of studying diffusion processes in polymer recording media. Optics and Spectroscopy, 1986, vol. 60, no. 1, pp. 87–91.

10. Ferry J.D. Viscoelastic Properties of Polymers. New York - London, 1961.

11. Mahilny U.V., Trofimova A.V. A new mechanism of stable optical birefringence recording under polarized UV radiation in photocrosslinking polymeric materials. Journal of Optics, 2011, vol. 13, no. 10, pp. 105601. https://doi.org/10.1088/2040-8978/13/10/105601

12. Mahilny U.V., Stankevich A.I. Intensification of holographic relief gratings recorded in layers of photo-crosslinking polymers. Collection of research papers of the VIII International Conference Photonics and Information Optics. Moscow, NRNU MEPhI, 2019, pp. 273–274. (in Russian)

13. Mahilny U.V. Stankevich A.I., Khramtsou E.A., Shkadarevich A.P. Photooxidation of anthracene-containing polymers with atmospheric oxygen for volume-phase and relief-phase holographic recording. Proc. of the 14th International Conference "Interaction of Radiation with Solids", Minsk, BSU, 2021, pp. 325–329. (in Russian)

14. Veniaminov A.V., Mahilny U.V. Holographic polymer materials with diffusion development: Principles, arrangement, investigation, and applications. Optics and Spectroscopy, 2013, vol. 115, no. 6, pp. 906–930. https://doi.org/10.1134/S0030400X13120199

15. Mahilny U.V., Marmysh D.N., Tolstik A.L., Matusevich V., Kowarschik R. Phase hologram formation in highly concentrated phenanthrenequinone–PMMA media. Journal of Optics A: Pure and Applied Optics, 2008, vol. 10, no 8, pp. 085302. https://doi.org/10.1088/1464-4258/10/8/085302

16. Nastas A.M., Iovu M.S. Analysis of the effect of relief depth on the diffraction efficiency of reflection and transmission phase-relief diffraction gratings. Technical Physics, 2015, vol. 60, no. 7, pp. 1077–1078. https://doi.org/10.1134/s106378421507018x

This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License